1 / 22

Solar Electric Energy Basics: System Design Considerations

Solar Electric Energy Basics: System Design Considerations. Frank R. Leslie B. S. E. E., M. S. Space Technology, LS IEEE Adjunct Professor, Florida Tech 9/29/2008, Rev. 1.3 fleslie @fit.edu; (321) 674-7377 my.fit.edu/~fleslie.  Does Energy Affect our Lives? .

lev-joyce
Download Presentation

Solar Electric Energy Basics: System Design Considerations

An Image/Link below is provided (as is) to download presentation Download Policy: Content on the Website is provided to you AS IS for your information and personal use and may not be sold / licensed / shared on other websites without getting consent from its author. Content is provided to you AS IS for your information and personal use only. Download presentation by click this link. While downloading, if for some reason you are not able to download a presentation, the publisher may have deleted the file from their server. During download, if you can't get a presentation, the file might be deleted by the publisher.

E N D

Presentation Transcript

  1. Solar Electric Energy Basics:System Design Considerations Frank R. Leslie B. S. E. E., M. S. Space Technology, LS IEEE Adjunct Professor, Florida Tech 9/29/2008, Rev. 1.3 fleslie @fit.edu; (321) 674-7377 my.fit.edu/~fleslie

  2.  Does Energy Affect our Lives?  Happy New Yorkers out for a Stroll! Are they having fun? Why did thishappen? FOXnews 8/15/2003 080820

  3. Energy Considerations for 2050 • Fossil-fuel energy will deplete in the future; millions of years to create that much fuel • US oil production peaked about 1974; world energy will peak about 2009 or so • Renewable energy will become mandatory, and our lifestyles may change • Transition to renewable energy must occur well before a crisis occurs

  4. Florida Energy Use Varies with the Time of Day (Daily Living) • Daily load peaking (1 a.m. to midnight graph)megawatts vs. hours http: 7 a.m. 3 - 7 p.m. 7 - 9 p.m. http://www.dep.state.fl.us/energy/fla_energy/files/energy_plan_final.pdf 080101

  5. Roof-top Solar Array Computations • Find the south-facing roof area; say 20 ft * 40 ft = 800 ft2 • Assume 120 Wp solar modules are 26 inches by 52 inches; 9.4 ft2/120 watt; 12.78 W/ft2 • Assume 90% of area can be covered, 720 ft2, ~9202 W • and that there are 5.5 effective hours of sun/day; 51 kWh/day • The south-facing modules are tilted south to the latitude angle • 76 modules would fit the area, but 44 would provide an average home with 30 kWh/day and cost ~$17600 for modules alone, ~one mile of powerline Siemens Solar SM110 Maximum power rating, 110 W Minimum power rating, 100 W Rated current. 6.3 A Rated voltage, 17.9 V Short circuit current, 6.9 A Open circuit voltage, 21.7 V

  6. PV Cell Basics • Semiconductor of transparent positive silicon and negative silicon backing • Incoming light (photons) cause energized electrons to move to the n-silicon and out the connector • Nominal voltage of 0.55 V requires series connections to get useful voltage, 16 V • Short circuit current is proportional to light intensity Maximum output when normal to cell is pointed at light (cosine of sun offset angle) Ref.: FSEC

  7. Energy Usage & Conservation • The loads supported by the system must be minimized to match the available energy • Load analysis shows the largest concerns that might be reduced to cut costs • Conservation by enhanced building insulation and reduced lighting loads • Increased efficiency of energy plants will conserve fossil fuels Arizona has clearer skies than Florida. Ref.: Innovative Power Systems

  8. PV System Decomposition intoFunctional Components Collect & Distribute Energy Collect Energy Regulate Energy Regulate Energy Store Energy Store Energy Start Control Energy Distribute Energy Use Energy Each function drives a part of the design, while the interfaces between them will be defined and agreed upon to ensure follow-on upgrades

  9. PV modules of 120 W cost about $400 Mounting angles to match sun --- fixed or tracking Average module slope angle is equal to latitude Zoning and regulations --- Not In My Back Yard (NIMBYs) problem Protection required for electric line workers due to “islanding” backfeed PV Systems This solar intensity plot for Cocoa FL shows the cloud effect on what otherwise would have been a cosine effect Ref.: FSEC

  10. Limits charge current to protect battery Disconnects battery if voltage falls too low (10.6 V is typical) Removes charge current if voltage rises too high (14V is typical) Shifts output of source to a load (water heater or electric furnace) if battery is fully charged Charge controller Soltek Mark IV 20 Amp Regulator “Big as a breadbox” for a 4 kW inverter

  11. Energy Storage • Energy may be stored chemically, in water behind high dams, electrically, flywheels, and compressed air caverns. • Hydrogen (like electricity) is an energy carrier, not a direct fuel source, but compressed H2 can also be stored • Hydrogen can be made by electrolysis of water or “cracking” methane • World's largest storage dam, Uganda's Owen Falls Dam. The hydroelectric station at the dam supplies most of the electricity requirements of Uganda, and parts of Kenya. (Photo:Faculty of Engineering, Kasetsart University, Thailand)

  12. Lead-acid (car) batteries most economical; but should be deep-cycle Critical rating is 20-hour value Charge cycle is ~60-70% efficient -- rather wasteful Requires maintenance to ensure long life A home might have ten of these batteries Storage Battery Soltek Deep-Cycle BatteryAP-2712 Vdc,115 A-hr 20-hour rate

  13. Inverter converts low voltage direct current to 120 Vac Loads can use low-voltage directly at higher efficiency Synchronous inverters may be “inter-tied” with power line to reduce billable energy In “net metering” states, the energy is metered at the same rate going into and out of the electrical grid --- no storage required! Inverter Trace Legend 4 kilowatt Inverter

  14. Household load analysis estimates the peak and average power and energy required Some might be reduced or time-shifted to decrease system costs Incandescent lamps produce far more heat than light; CFLs provide ~100 W light equivalent at 27 W load Loads 27 watt (100 W equivalent)Compact Fluorescent Lamp (CFL) CFL Costs without replacement labor: $21.30 Incandescent Costs with replacement labor: $39.98 ____________________________________ CFL Costs with replacement labor: $23.30 Incandescent Costs with replacement labor: $56.54 Hint: You can buy a CFL at a large local discount store for $4.68!

  15. Energy Transmission • Energy transmission lines may lose 5% en route • Only three electrical grids for all Contiguous US (CONUS) • Mine-head coal plants avoid coal trains and the power to drive them • Hydrogen pipelines could transport gaseous energy cheaply and parallel natural gas lines Guyed transmission tower with multiple conductor spreaders (note at left) to increase current capacity or reduce loss

  16. Energy in Transportation • Air and ground transportation requires energy-dense fuels (liquids) • Fixed natural gas plants compete with CNG for cars and trucks • Research is on-going with a Lear jet fueled with hydrogen from two large high-pressure vessels running lengthwise over the passenger compartment -- a dubious location Compressed natural gas car at FSEC

  17. Generic Trades in Energy • Energy trade-offs required to make rational decisions • PV is expensive ($5 per watt for hardware + $5 per watt for shipping and installation = $10 per watt) compared to wind energy ($1.5 per watt for hardware + $5 per watt for installation = $6 per watt total) • Are Compact Fluorescent Lamps (CFLs) better to use? Ref.: www.freefoto.com/pictures/general/ windfarm/index.asp?i=2 Ref.: http://www.energy.ca.gov/education/story/story-images/solar.jpeg Photo of FPL’s Cape Canaveral Plant by F. Leslie, 2001

  18. Conclusion • Solar electric energy is best applied where the cost justifies; remote from the grid • Costs of fossil-fuel pollution and subsidies are not easily found -- controversies exist • PV costs are falling, but fossil-fuel costs will soon surpass them • At that time, PV will compete with wind energy, which is currently competitive with fossil fuels

  19. Thank you! Questions? ? ? My website: my.fit.edu/~fleslie for presentations Roberts Hall weather and energy data: my.fit.edu/wx_fit/roberts/RH.htm DMES Meteorology Webpage: my.fit.edu/wx_fit/?q=obs/realtime/roberts 080710

  20. Is a Solar Roof Practical? Sun intensity at surface ~1000 watt / square meterPV cells about 15% efficient = ~150 watt / square meter Roof might be about 20 x 40 feet = 800 square feet; 90% coverage = 720 square feet A 120 watt solar module is about 26 inches x 52 inches = ~ 9.4 sq. ft, thus peak power production is ~12.78 watt / square ft 720 square feet*(12.8 watt/square feet) = 9202 watts peak power Optimally, roof array could yield 9202 watts for 5.5 hours/average day = 51 kWh each day on average; average house might need 30 kWh Storage would provide energy at night and during cloudy weather, but increases the cost Current cost estimates are about $5/W & $0.06 to $0.20 per kWh vs. $0.07 from utility Utility line extension costs about $18,000 to $50,000 per mile

  21. References: Books, etc. • Brower, Michael. Cool Energy. Cambridge MA: The MIT Press, 1992. 0-262-02349-0, TJ807.9.U6B76, 333.79’4’0973. • Duffie, John and William A. Beckman. Solar Engineering of Thermal Processes. NY: John Wiley & Sons, Inc., 920 pp., 1991 • Home Power magazine. Ashland OR. www.homepower.com

  22. References: Internet • http://geothermal.marin.org/ on geothermal energy • http://mailto:energyresources@egroups.com • http://www.dieoff.org. Site devoted to the decline of energy and effects upon population • http://www.ferc.gov/ Federal Energy Regulatory Commission • http://www.humboldt1.com/~michael.welch/extras/battvoltandsoc.pdf • http://www.siemenssolar.com/sm110_sm100.html PV Array • http://www.soltek.ca/products/solarmod.htm • http://www.soltek.ca/index.htm • http://www.ips-solar.com/yourproject/costanalysis.htm Cost analysis • http://www.ips-solar.com/yourproject/resource.htm Energy analysis • http://www.aep.com/Environmental/solar/power/ch5.htm Renewable energy • http://ens.lycos.com/ens/dec2000/2000L-12-01-01.html

More Related