1 / 41

direct assessment basics

Why Direct Assessment?. Alternative to ILI or Hydro Test When Not Feasible or PracticalMany Gas Transmission Pipelines are

Jimmy
Download Presentation

direct assessment basics

An Image/Link below is provided (as is) to download presentation Download Policy: Content on the Website is provided to you AS IS for your information and personal use and may not be sold / licensed / shared on other websites without getting consent from its author. Content is provided to you AS IS for your information and personal use only. Download presentation by click this link. While downloading, if for some reason you are not able to download a presentation, the publisher may have deleted the file from their server. During download, if you can't get a presentation, the file might be deleted by the publisher.

E N D

Presentation Transcript


    1. Direct Assessment Basics Richard Lopez Office of Pipeline Safety Southwest Region

    2. Industry has estimated that to make lines piggable would cost somewhere between $90 to 700 Billion. Industry has estimated that to make lines piggable would cost somewhere between $90 to 700 Billion.

    3. Why Direct Assessment? ILI or Hydro-testing Could Cause Customer Supply Interruptions LDC Laterals Often Sole Source Supply Pipeline Safety Improvement Act 2002 – Section 23 TPSSC Equivalency Recommendation Industry has estimated that to make lines piggable would cost somewhere between $90 to 700 Billion. Industry has estimated that to make lines piggable would cost somewhere between $90 to 700 Billion.

    4. Factors Impeding Piggability Telescopic Connections Small Diameter Pipelines Short Pipelines Sharp Radius Bends Not “piggable” involves pipe with varying diameters, short radius bends, reduced opening and pipe restrictions, as well as operating pressures too low to move pigs in a pipeline at controlled speeds, without exceeding MAOP if pigs get stuck and increased pressure is needed to dislodge them. Not “piggable” involves pipe with varying diameters, short radius bends, reduced opening and pipe restrictions, as well as operating pressures too low to move pigs in a pipeline at controlled speeds, without exceeding MAOP if pigs get stuck and increased pressure is needed to dislodge them.

    5. Factors Impeding Piggability Less than Full Opening Valves No Alternate Supply if Pig is “Hung Up” Low Pressure & Low Flow Conditions Scheduling and Coordination is an Anti-trust Issue Not “piggable” involves pipe with varying diameters, short radius bends, reduced opening and pipe restrictions, as well as operating pressures too low to move pigs in a pipeline at controlled speeds, without exceeding MAOP if pigs get stuck and increased pressure is needed to dislodge them. Not “piggable” involves pipe with varying diameters, short radius bends, reduced opening and pipe restrictions, as well as operating pressures too low to move pigs in a pipeline at controlled speeds, without exceeding MAOP if pigs get stuck and increased pressure is needed to dislodge them.

    6. Features in Common with ILI Indirect Examinations Validation/Excavation/Direct Exam Integrate & Analyze Data Identify & Address Data Gaps Identify Remediation Needs Determine Re-assessment Intervals Obtaining as much Information about a pipeline is a key ingredient to the IMP processes. To refine and define the threats to the pipeline, possibly reduce the threat and the uncertainty, often it is desirable and economical to obtain more data about pipeline conditions and characteristics. Operators search their records for all available information and data about a pipeline’s physical characteristics, construction conditions, and its operating history, (corrosion locations, when CP was fists applied, lost, etc, and where any leaks occurred. Indirect tools use aboveground diagnostic tools to locate and help prioritize indications. Direct tools excavate at indications and examine pipe to better understand what is happening to the pipeline. Methods use the results of examinations for total pipeline assessment. Remediation Needs may involve pipe replacements, pipe repairs, coating reconditioning, etc. Evaluating and confirming a pipeline’s integrity involves assessing the remaining risks, reordering anomaly and excavation priorities, and implementing preventive and mitigation programs to reduce or eliminate continued threats to the P/L. Re-inspection intervals involves applying defect growth models to determine safe operating conditions and to determine intervals for inspection and when the pipe must be re-evaluated. Obtaining as much Information about a pipeline is a key ingredient to the IMP processes. To refine and define the threats to the pipeline, possibly reduce the threat and the uncertainty, often it is desirable and economical to obtain more data about pipeline conditions and characteristics. Operators search their records for all available information and data about a pipeline’s physical characteristics, construction conditions, and its operating history, (corrosion locations, when CP was fists applied, lost, etc, and where any leaks occurred. Indirect tools use aboveground diagnostic tools to locate and help prioritize indications. Direct tools excavate at indications and examine pipe to better understand what is happening to the pipeline. Methods use the results of examinations for total pipeline assessment. Remediation Needs may involve pipe replacements, pipe repairs, coating reconditioning, etc. Evaluating and confirming a pipeline’s integrity involves assessing the remaining risks, reordering anomaly and excavation priorities, and implementing preventive and mitigation programs to reduce or eliminate continued threats to the P/L. Re-inspection intervals involves applying defect growth models to determine safe operating conditions and to determine intervals for inspection and when the pipe must be re-evaluated.

    7. Factors Impeding Hydro-Test Service Interruptions Sole Source Supplies Concerns of Causing Pipeline Damage Dewatering Concerns/Difficult to Dry Concerns have been stated that hydro testing grows pipe imperfections and cracks, may do more harm to the pipeline than verify a lines’ integrity, and may result in supply interruptions if water is not completely removed after testing, and may even foster internal corrosion.Concerns have been stated that hydro testing grows pipe imperfections and cracks, may do more harm to the pipeline than verify a lines’ integrity, and may result in supply interruptions if water is not completely removed after testing, and may even foster internal corrosion.

    8. Factors Impeding Hydro-Test Dewatering Concerns/Difficult to Dry Growth of Sub-critical Defects Water Availability & Disposal No Characterization of Future Risk Concerns have been stated that hydro testing grows pipe imperfections and cracks, may do more harm to the pipeline than verify a lines’ integrity, and may result in supply interruptions if water is not completely removed after testing, and may even foster internal corrosion.Concerns have been stated that hydro testing grows pipe imperfections and cracks, may do more harm to the pipeline than verify a lines’ integrity, and may result in supply interruptions if water is not completely removed after testing, and may even foster internal corrosion.

    9. DA Basics - Overview Distinct Assessment Process for each Applicable Threat (i.e., EC, IC, & SCC) Scope of DA as an IM Assessment is more Limited than either ILI or Hydro What is critical for success in using the Direct assessment process is: Expertise, skill, and experience in understanding and implementing the NACE ECDA, ICDA and SCC Standards. Processes of gathering, integration and analysis of data both historical to the pipeline and newly obtained data. Mechanical Damage detection (or third party damage (TPD)) by ECDA will be limited by presence of coating holidays. It is important to understand the limits of any IMP approach, what threats can be expected and what tools are capable of addressing that threat. If a pipeline is expected to contain failure threats other than those that may be discovered by DA tools, such as material defects, cracks at welds, design or construction defects, low toughness levels, gouges covered over, etc, other tools must supplement DA tools to address these. Stress that assessment and integration and analysis of data during all steps of the DA process is very important. There are some advantages compared with Hydro and ILI as we’ll see a bit later.What is critical for success in using the Direct assessment process is: Expertise, skill, and experience in understanding and implementing the NACE ECDA, ICDA and SCC Standards. Processes of gathering, integration and analysis of data both historical to the pipeline and newly obtained data. Mechanical Damage detection (or third party damage (TPD)) by ECDA will be limited by presence of coating holidays. It is important to understand the limits of any IMP approach, what threats can be expected and what tools are capable of addressing that threat. If a pipeline is expected to contain failure threats other than those that may be discovered by DA tools, such as material defects, cracks at welds, design or construction defects, low toughness levels, gouges covered over, etc, other tools must supplement DA tools to address these. Stress that assessment and integration and analysis of data during all steps of the DA process is very important. There are some advantages compared with Hydro and ILI as we’ll see a bit later.

    10. DA Basics - Overview May be the Assessment Method of Choice (esp. for Non-piggable Lines and Low-Stress Gas Lines that cannot be Hydro Tested) Involves Integration of Risk Factor Data to Identify Potential Threats What is critical for success in using the Direct assessment process is: Expertise, skill, and experience in understanding and implementing the NACE ECDA, ICDA and SCC Standards. Processes of gathering, integration and analysis of data both historical to the pipeline and newly obtained data. Mechanical Damage detection (or third party damage (TPD)) by ECDA will be limited by presence of coating holidays. It is important to understand the limits of any IMP approach, what threats can be expected and what tools are capable of addressing that threat. If a pipeline is expected to contain failure threats other than those that may be discovered by DA tools, such as material defects, cracks at welds, design or construction defects, low toughness levels, gouges covered over, etc, other tools must supplement DA tools to address these. Stress that assessment and integration and analysis of data during all steps of the DA process is very important. There are some advantages compared with Hydro and ILI as we’ll see a bit later.What is critical for success in using the Direct assessment process is: Expertise, skill, and experience in understanding and implementing the NACE ECDA, ICDA and SCC Standards. Processes of gathering, integration and analysis of data both historical to the pipeline and newly obtained data. Mechanical Damage detection (or third party damage (TPD)) by ECDA will be limited by presence of coating holidays. It is important to understand the limits of any IMP approach, what threats can be expected and what tools are capable of addressing that threat. If a pipeline is expected to contain failure threats other than those that may be discovered by DA tools, such as material defects, cracks at welds, design or construction defects, low toughness levels, gouges covered over, etc, other tools must supplement DA tools to address these. Stress that assessment and integration and analysis of data during all steps of the DA process is very important. There are some advantages compared with Hydro and ILI as we’ll see a bit later.

    11. Keys to Successful DA Expertise, Skill, Experience Follow NACE Standards Document Justifications for Not Implementing “Should” and “May” Recommendations in the Standards Documents Reasons for Program Decisions and Options Selected Take some time here to explain some keys to successfully implementing a DA approach. What is critical for success in using the Direct assessment process is: Expertise, skill, and experience in understanding and implementing the NACE ECDA, ICDA and SCC Standards. Processes of gathering, integration and analysis of data both historical to the pipeline and newly obtained data. Stress that assessment and integration and analysis of data during all steps of the DA process is very important. The amount of data and the quality of data will be a key to successful application of DA. Examples of the Types of Data that will be required: Design and pipe characteristics Materials of construction Construction practices Cathodic protection application history CP survey data Repair and maintenance history (including pipe inspection reports) Locations of 3rd party construction Locations of components and appurtenances (valves, taps, supports, clamps, sleeves, casings, etc.) Soil characteristics Other integrity surveys or tests (ILI runs) Take some time here to explain some keys to successfully implementing a DA approach. What is critical for success in using the Direct assessment process is: Expertise, skill, and experience in understanding and implementing the NACE ECDA, ICDA and SCC Standards. Processes of gathering, integration and analysis of data both historical to the pipeline and newly obtained data. Stress that assessment and integration and analysis of data during all steps of the DA process is very important. The amount of data and the quality of data will be a key to successful application of DA. Examples of the Types of Data that will be required: Design and pipe characteristics Materials of construction Construction practices Cathodic protection application history CP survey data Repair and maintenance history (including pipe inspection reports) Locations of 3rd party construction Locations of components and appurtenances (valves, taps, supports, clamps, sleeves, casings, etc.) Soil characteristics Other integrity surveys or tests (ILI runs)

    12. Keys to Successful DA (cont.) Data Management Collection, Integration, Analysis Data Quality Understand Limitations of DA Provide Detailed Procedures for All Process Steps Take some time here to explain some keys to successfully implementing a DA approach. What is critical for success in using the Direct assessment process is: Expertise, skill, and experience in understanding and implementing the NACE ECDA, ICDA and SCC Standards. Processes of gathering, integration and analysis of data both historical to the pipeline and newly obtained data. Stress that assessment and integration and analysis of data during all steps of the DA process is very important. The amount of data and the quality of data will be a key to successful application of DA. Examples of the Types of Data that will be required: Design and pipe characteristics Materials of construction Construction practices Cathodic protection application history CP survey data Repair and maintenance history (including pipe inspection reports) Locations of 3rd party construction Locations of components and appurtenances (valves, taps, supports, clamps, sleeves, casings, etc.) Soil characteristics Other integrity surveys or tests (ILI runs) Take some time here to explain some keys to successfully implementing a DA approach. What is critical for success in using the Direct assessment process is: Expertise, skill, and experience in understanding and implementing the NACE ECDA, ICDA and SCC Standards. Processes of gathering, integration and analysis of data both historical to the pipeline and newly obtained data. Stress that assessment and integration and analysis of data during all steps of the DA process is very important. The amount of data and the quality of data will be a key to successful application of DA. Examples of the Types of Data that will be required: Design and pipe characteristics Materials of construction Construction practices Cathodic protection application history CP survey data Repair and maintenance history (including pipe inspection reports) Locations of 3rd party construction Locations of components and appurtenances (valves, taps, supports, clamps, sleeves, casings, etc.) Soil characteristics Other integrity surveys or tests (ILI runs)

    13. Today’s Discussion will Focus on ECDA NACE RP0502 has been Issued ECDA Process is More Mature than ICDA or SCCDA Overview of NACE RP0502 Process for ECDA PSIA of 2002 requires OPS to address DA, this OPS NPRM or one in future will reference the standard, and TPSSC recommended that OPS consider DA equivalent to ILI and Hydro. The NACE Std on ECDA has been issued. So today we will focus on ECDA. It is a more mature and better understood technique. NACE will brief you later today on the status of development of standards for ICDA and SCCDA. ECDA is a process to find Holidays, breaks in a pipeline’s coating, where corrosion can attack the pipe wall and reduce its safety margin of operation. Mechanical Damage detection (or third party damage (TPD)) by ECDA will be limited by presence of coating holidays. It is important to understand the limits of any IMP approach, what threats can be expected and what tools are capable of addressing that threat. If a pipeline is expected to contain failure threats other than those that may be discovered by DA tools, such as material defects, cracks at welds, design or construction defects, low toughness levels, gouges covered over, etc, other tools must supplement DA tools to address these. PSIA of 2002 requires OPS to address DA, this OPS NPRM or one in future will reference the standard, and TPSSC recommended that OPS consider DA equivalent to ILI and Hydro. The NACE Std on ECDA has been issued. So today we will focus on ECDA. It is a more mature and better understood technique. NACE will brief you later today on the status of development of standards for ICDA and SCCDA. ECDA is a process to find Holidays, breaks in a pipeline’s coating, where corrosion can attack the pipe wall and reduce its safety margin of operation. Mechanical Damage detection (or third party damage (TPD)) by ECDA will be limited by presence of coating holidays. It is important to understand the limits of any IMP approach, what threats can be expected and what tools are capable of addressing that threat. If a pipeline is expected to contain failure threats other than those that may be discovered by DA tools, such as material defects, cracks at welds, design or construction defects, low toughness levels, gouges covered over, etc, other tools must supplement DA tools to address these.

    14. Limitations of ECDA ECDA Can Not Deal With: Lines Susceptible to Seam Failure Near-neutral pH SCC Fatigue Failures in Liquid Lines Internal Corrosion Plastic Pipe Pipe in Shielded Areas The NACE Std on ECDA has been issued. So today we will focus on ECDA. It is a more mature and better understood technique. NACE will brief you later today on the status of development of standards for ICDA and SCCDA. ECDA is a process to find Holidays, breaks in a pipeline’s coating, where corrosion can attack the pipe wall and reduce its safety margin of operation. Mechanical Damage detection (or third party damage (TPD)) by ECDA will be limited by presence of coating holidays. It is important to understand the limits of any IMP approach, what threats can be expected and what tools are capable of addressing that threat. If a pipeline is expected to contain failure threats other than those that may be discovered by DA tools, such as material defects, cracks at welds, design or construction defects, low toughness levels, gouges covered over, etc, other tools must supplement DA tools to address these. The NACE Std on ECDA has been issued. So today we will focus on ECDA. It is a more mature and better understood technique. NACE will brief you later today on the status of development of standards for ICDA and SCCDA. ECDA is a process to find Holidays, breaks in a pipeline’s coating, where corrosion can attack the pipe wall and reduce its safety margin of operation. Mechanical Damage detection (or third party damage (TPD)) by ECDA will be limited by presence of coating holidays. It is important to understand the limits of any IMP approach, what threats can be expected and what tools are capable of addressing that threat. If a pipeline is expected to contain failure threats other than those that may be discovered by DA tools, such as material defects, cracks at welds, design or construction defects, low toughness levels, gouges covered over, etc, other tools must supplement DA tools to address these.

    15. Limitations of ECDA ECDA has Limited Applicability to: Mechanical Damage (Only to the Degree that Coating is also Damaged) The NACE Std on ECDA has been issued. So today we will focus on ECDA. It is a more mature and better understood technique. NACE will brief you later today on the status of development of standards for ICDA and SCCDA. ECDA is a process to find Holidays, breaks in a pipeline’s coating, where corrosion can attack the pipe wall and reduce its safety margin of operation. Mechanical Damage detection (or third party damage (TPD)) by ECDA will be limited by presence of coating holidays. It is important to understand the limits of any IMP approach, what threats can be expected and what tools are capable of addressing that threat. If a pipeline is expected to contain failure threats other than those that may be discovered by DA tools, such as material defects, cracks at welds, design or construction defects, low toughness levels, gouges covered over, etc, other tools must supplement DA tools to address these. The NACE Std on ECDA has been issued. So today we will focus on ECDA. It is a more mature and better understood technique. NACE will brief you later today on the status of development of standards for ICDA and SCCDA. ECDA is a process to find Holidays, breaks in a pipeline’s coating, where corrosion can attack the pipe wall and reduce its safety margin of operation. Mechanical Damage detection (or third party damage (TPD)) by ECDA will be limited by presence of coating holidays. It is important to understand the limits of any IMP approach, what threats can be expected and what tools are capable of addressing that threat. If a pipeline is expected to contain failure threats other than those that may be discovered by DA tools, such as material defects, cracks at welds, design or construction defects, low toughness levels, gouges covered over, etc, other tools must supplement DA tools to address these.

    16. 4 Step ECDA Process of NACE RP0502 Pre-assessment Indirect Assessment Direct Physical Examination Post-assessment Basic concept is similar to ILI (pigging). Technologies can be used as a diagnostic tool to assess pipeline integrity. Defect growth models can be used to determine “safe” operating conditions and to determine re-assessment or inspection frequencies. Direct Assessment diagnostic techniques generate data concerning integrity characteristics. Throughout each of the process steps, integration of data from inspection tools and historical data and operational data leads to assessments of the overall health of the pipeline system. Basic concept is similar to ILI (pigging). Technologies can be used as a diagnostic tool to assess pipeline integrity. Defect growth models can be used to determine “safe” operating conditions and to determine re-assessment or inspection frequencies. Direct Assessment diagnostic techniques generate data concerning integrity characteristics. Throughout each of the process steps, integration of data from inspection tools and historical data and operational data leads to assessments of the overall health of the pipeline system.

    17. Pre-assessment Process Similar to Risk Assessment Assemble and Analyze Risk Factor Data Pre-Assessment Data collection Threat Analysis ECDA feasibility for pipeline Indirect inspection tool selection ECDA region identification Pre-Assessment Data collection Threat Analysis ECDA feasibility for pipeline Indirect inspection tool selection ECDA region identification

    18. Pre-assessment Purpose: Determine Whether ECDA Process is Appropriate and Define “ECDA Regions” Select Appropriate Indirect Inspection Tools (e.g., CIS, DCVG, PCM, C-SCAN) Complementary Primary and Secondary Tools are Required Identify Inspection Expectations Pre-Assessment Data collection Threat Analysis ECDA feasibility for pipeline Indirect inspection tool selection ECDA region identification Pre-Assessment Data collection Threat Analysis ECDA feasibility for pipeline Indirect inspection tool selection ECDA region identification

    19. Pre-assessment Data Collection (Table 1 of NACE Standard) Pipe Related Construction Related Soils/Environmental Corrosion Protection Pipeline Operations

    20. Pre-assessment ECDA Indirect Insp. Tool Feasibility Complementary Tools – Evaluate pipe with different technologies (see table 2 of NACE RP0502)

    21. Pre-assessment Feasibility Influenced by: Degree of Shielding (Coating type, Terrain) Accessibility (Pavement, Water Crossings, Casings)

    22. Pre-assessment Establish ECDA feasibility regions Determine which indirect methods are applicable to each region Tools may vary from region to region

    23. Pre-assessment What is a Region? Segment is a Continuous Length of Pipe Regions are Subsets of One Segment Characterized by Common Attributes Pipe with Similar Construction and Environmental Characteristics Use of Same Indirect Inspection Tools Throughout the Region is Appropriate

    24. Indirect Inspection Close Interval Survey (CIS) Direct Current Voltage Gradient (DCVG) C-Scan Pipeline Current Mapper (PCM) Alternating Current Voltage Gradient (ACVG) (PCM with A-Frame) Examples of the kinds of tools that may be used in ECDA. Examples of the kinds of tools that may be used in ECDA.

    25. Indirect Inspection Pearson Ultrasonic Waveform Soil Resistivity, Pipe Depth Examples of the kinds of tools that may be used in ECDA. Examples of the kinds of tools that may be used in ECDA.

    26. Indirect Inspection Direct Current Measure Structure Potential Identify Locations of High CP Demand to Small Area

    27. Indirect Inspection Alternating Current Apply AC signal Determine Amount of Current Drain (i.e., Grounding) and Location Identify Locations of High AC Current

    28. Indirect Inspection Types of Direct Current Tools Close Interval Survey (CIS or CIPS) Direct Current Voltage Gradient (DCVG) Types of Alternating Current Tools Alternating Current Voltage Gradient (ACVG) Pearson Survey AC Attenuation (PCM, EM, C-Scan)

    29. Indirect Inspection Purpose: Locate Areas Where Coating Damage May Exist Evaluate Whether Corrosion Activity is Present Apply Primary and Secondary Tools Indirect Examination Objective: Identify coating faults and areas where corrosion activity may have or may be occurring. The step utilizes a minimum of two complementary indirect techniques or tools. Also, extremely important to correlate geospatial tool data – locations where readings are being taken, along with documenting surface conditions, other utility facilities at the location of the readings, trench indications, etc, along with operating history data Indirect Examination Objective: Identify coating faults and areas where corrosion activity may have or may be occurring. The step utilizes a minimum of two complementary indirect techniques or tools. Also, extremely important to correlate geospatial tool data – locations where readings are being taken, along with documenting surface conditions, other utility facilities at the location of the readings, trench indications, etc, along with operating history data

    30. Indirect Inspection Timing Such That Conditions are Same Overlay and Evaluate Data for Clarity, Quality, and Consistency Distance Correlation Should be Good Indirect Examination Objective: Identify coating faults and areas where corrosion activity may have or may be occurring. The step utilizes a minimum of two complementary indirect techniques or tools. Also, extremely important to correlate geospatial tool data – locations where readings are being taken, along with documenting surface conditions, other utility facilities at the location of the readings, trench indications, etc, along with operating history data Indirect Examination Objective: Identify coating faults and areas where corrosion activity may have or may be occurring. The step utilizes a minimum of two complementary indirect techniques or tools. Also, extremely important to correlate geospatial tool data – locations where readings are being taken, along with documenting surface conditions, other utility facilities at the location of the readings, trench indications, etc, along with operating history data

    31. Indirect Inspection via CIS May Detect Large Coating Holidays Measure Pipe to Soil Potential at Regular Intervals (2.5 – 5 ft. Desirable) Protection criteria -850mV polarized potential 100mV polarization

    32. Indirect Inspection via CIS Secondary Interpretation Change in potential profile Amount of IR drop (Low or High) ON and OFF Readings are Desirable

    33. Indirect Inspection via DCVG Measures Voltage Gradient in Soil CP Current Greatest Where Coating is Damaged V = I*R ?V = ?I*R V = I*R ?V = ?I*R

    34. Indirect Inspection via DCVG Interrupt Rectifier to Determine ?V One Electrode Two Electrodes Parallel or perpendicular to ROW Coating Holiday Size Indicated by % ?V Triangulation Used to Locate Holiday V = I*R ?V = ?I*R V = I*R ?V = ?I*R

    35. Indirect Inspection via ACVG Impose AC current Measure Gradient Between 2 Electrodes Spaced ~1m Apart Gradient Corresponds to Current Flow

    36. Direct Physical Examination Establish “Priority Categories” from Indirect Inspection Excavations for Direct Examination

    37. Direct Physical Examination Purpose: Confirm Presence of Corrosion Activity Determine Need for Repair or Mitigation Evaluate Likely Corrosion Growth Rate Support Adjustments to Excavation Scope Evaluate Need for Other Technology

    38. Direct Physical Examination Categorize Indications Immediate Action Required Schedule for Action Required Suitable for Monitoring Excavate and Collect Data Where Corrosion is Most Likely

    39. Direct Physical Examination Characterize Coating and Corrosion Anomalies Establish Corrosion Severity for Remaining Strength Analysis Determine Root Cause

    40. Direct Physical Examination In-process Evaluation, Re-categorization, Guidelines on Number of Direct Examinations All “Immediate” Must be Excavated Prioritize “Scheduled” & “Monitored” If >20% Wall Loss Found, Examine at Least 1 More (2 More for 1st ECDA)

    41. Direct Physical Examination If No Indications At Least 1, and 2 for 1st ECDA Choose More Corrosive Region

    42. Direct Physical Examination Dig a Bell Hole Visual Inspection Coating Condition Ultrasonic Testing Radiography Soil Chemistry and Resistivity

    43. Direct Physical Examination Collect Data at Dig Site Pipe to Soil Potentials Soil Resistivity Soil and Water Sampling Under-film pH Bacteria & SCC Related Data Photographic Documentation

    44. Direct Physical Examination Characterize Coating and Corrosion Anomalies Coating Condition Adhesion, Under Film Liquid, % Bare Corrosion Analysis Corrosion Morphology Classification Damage Mapping MPI Analysis for SCC

    45. Direct Physical Examination Remaining Strength Analysis ASME B31G RSTRENG

    46. Direct Physical Examination Determine Root Cause For Example Low CP Interference MIC Disbonded Coatings Construction Practices 3rd Party Damage

    47. Post-Assessment Evaluates Composite Set of Data and Assessment Results Sets Re-inspection Intervals Validates ECDA Process This step may result in reordering priorities of anomalous conditions, It may identify continuing excavation needs for further evaluations and more data upon which to base a decision and eliminate uncertainty of as to whether further work is required. It may identify the need for other assessment technologies I.e. ILI especially if numerous conditions are identified with ECDA tools, too numerous to dig all of them and analyze the pipe at each location. This step may result in reordering priorities of anomalous conditions, It may identify continuing excavation needs for further evaluations and more data upon which to base a decision and eliminate uncertainty of as to whether further work is required. It may identify the need for other assessment technologies I.e. ILI especially if numerous conditions are identified with ECDA tools, too numerous to dig all of them and analyze the pipe at each location.

    48. Post-Assessment Remaining Life - Maximum Flaw Maximum Remaining Flaw Size Taken Same as Most Severe that was Found Second Maximum if Unique If No Corrosion Defects, Same as New Other (e.g., Statistical)

    49. Post-Assessment Remaining Life Growth Rate Measured Corrosion Rate Maximum Depth / Burial Time 16mpy (80% C.I. for Corrosion Tests) 0.3mm/y if at Least 40mV CP Demonstrated

    50. Post-Assessment Linear Polarization Resistance (LPR) Probe or Existing Buried Coupon Coupon Retrieval Assess ECDA Effectiveness

    51. Post-Assessment Perform at Least 1 Extra Dig at Random Location Pipe Condition Should be Better than at Indications For 1st ECDA Additional Dig at Low Priority Indication Company-specific Performance Metrics

    52. ECDA Summary There is No Panacea for Pipe Integrity Verification All Tools Have Limitations External Corrosion Direct Assessment is Based on the Use and Integration of Existing and Emerging Technologies

    53. ECDA Summary External Corrosion Direct Assessment can be Effective if Properly Applied Requires Effective Data Collection and Management as well as a Commitment to Validation Operators Choose Best Tools to Achieve Pipeline Reliability, Safety, and Asset Preservation

More Related